Search results

  1. Fordseniormaster

    Front Diff Fail Cont’d

    If the front axle shaft is removed the (spindle seal) has to be replaced, can't be reused. I'm sure a tech in this position wouldn't dare reuse a one-time use part. Noises are the worst thing we get to diag, we all hear noises differently, but once a customer gets dialed into one certain noise...
  2. Fordseniormaster

    6.7 Leak at passenger Bell Housing

    Yes, we have done a few on a 2020, but I keep forgetting this forum is basically a 2020 up deal! We are currently doing 3 now in the shop all pre 2020 though. The 20 up does have a gasket and better design all around than the earlier ones.
  3. Fordseniormaster

    6.7 Leak at passenger Bell Housing

    Upper Oil pan, we do quite a bit of them for that concern. Upper pan uses silicone have to be really clean and prepped properly to get it to seal properly.
  4. Fordseniormaster

    New Tremor dropping parts

    Probably an extra one they dropped during assembly. We find all kinds of extra parts during PDI's and while working on low mile vehicles. I think when they are on the line it's easier to grab another part rather than to fish out the one they drop. But that vent goes on top of the transmission if...
  5. Fordseniormaster

    Procharger vs Whipple

    My wife drives a 14 Raptor with the Whipple, and I would personally go with a Whipple on my Tremor for sure. The Whipple has great daily drivability for everyday use.
  6. Fordseniormaster

    Transfer Flow 58 gallon replacement tanks are finally being sold and installed!!!!

    I did the installation myself, I am a Ford Senior Master technician, but the install can be done by anyone that has a decent mechanical background. The one thing I've seen is people use impacts on the fuel tank strap bolts and break the nut cages. At no point should an impact be used to remove...
  7. Fordseniormaster

    FOR SALE DECKED Drawer System (2020-22)

    If you close i would buy today
  8. Fordseniormaster

    FORD ESP experience

    ESP is as good as you the Service dept using it, there is ways to escalate the repair to a unit if the parts are not readily available. The TSB you are referencing does not fix many of the 10R140's we see as it's just a main control overhaul not a transmission overhaul. If the dealer tried to...
  9. Fordseniormaster

    STOLEN FORD TRUCK THIEF SHOT!!!

    Fool got what he deserved!! This country has gone to shit, more of this is to come I promise people are tired of being the victims! I'm sure his family says he was the best hardest working guy they knew also. I'm just glad it happened in area where law and order is still present and people are...
  10. Fordseniormaster

    2023 6.7 HO Oil Change Intervals

    5K is the most i would ever go. My customer with the 600k mile is proof it works. I think any more than that is too much. But it's my opinion not all will agree I'm just stating what we see in the shop every day. Probally gonna get a lot of heat from my thoughts on this subject and most the time...
  11. Fordseniormaster

    2023 6.7 HO Oil Change Intervals

    I'm inside these engines every day, I can tell you the ones we work on most of the time are the higher mileage oil change guys. I have a hot Shotter with 600miles on his and he changes his oil every 5k miles which is like every 2 weeks most the time. I've been with Ford since 1990 and I truly...
  12. Fordseniormaster

    Boats and HOmes!

    My new Phoenix
  13. IMG_7163.jpg

    IMG_7163.jpg

  14. IMG_7159.jpg

    IMG_7159.jpg

  15. Fordseniormaster

    CANDID CP4 DISCUSSION WITH DEALERSHIP SERVICE MANAGER

    That has to be one the dumbest remarks I've ever seen!
  16. Fordseniormaster

    AFTER MARKET BATTERY (S)

    I replaced both of mine with the Odyssey's I had 2 set's of Motorcraft's within the first 15k miles and both sets leaked like crazy, so on the last warranty set, I installed the Odysseys and keep the new motorcrafts for my old 7.3 dually.
  17. Fordseniormaster

    Truck in dealer for cp4

    We find rust in the rails and other parts of the high pressure system which is a dead giveaway for water, as soon as we find rust and a pump failure it gets a complete system.
  18. Fordseniormaster

    Truck in dealer for cp4

    I have 4 in the shop as we speak, all waiting on parts. Have 2 at the house waiting on parts also, they seem to run in spells around here, kind of like they all get a bad batch of fuel somewhere as all of these have evidence of water in them. Good for techs but sucks for the customers waiting on...
Back
Top